|
|
Sanibest - Two Piece Round Bowl Toilet with Sanibest Grinder Pump - White
| With Sanibest, Saniflo introduces a new sophisticated heavy-duty system that stretches the limits of bathroom installation. Sanibest makes it possible to install bathroom appliances or a complete bathroom in a location where previously it would have been impossible - up to 18 feet below the sewer line or up to 150 feet away from a soil stack. In addition to toilet waste, Sanibest can efficiently discharge gray water from a hand basin, a bath, bidet, urinal, even a clothes washer (indirectly only). Sanibest is the only point-of-use grinder pump on the market. Recommended for rental units and situations where flushing sanitary articles might become a concern. | |
Toilet Seat Included : No Type : Injector Pump Bowl Type : Round Front Collection : Sanibest Sanibest - Two Piece Round Bowl Toilet with Sanibest Grinder Pump - White
- The Sanibest system includes: Round toilet bowl, toilet tank, and macerating unit. (TOILET SEAT NOT INCLUDED)
- While most of the Saniflo's range are basically shredders, the Sanibest incorporates an actual grinder system.
- Sanibest is ideal for situations where you do not control the use of it; i.e. rental unit, offices, warehouses, etc.
- Sanibest is designed to deal with sanitary articles that may have been flushed down the toilet by accident.
- Sanibest is a system that is used to install a complete bathroom up to 18 feet below the sewer line, or even up to 150 feet away from a soil stack.
- The toilet uses only 6 liters (1.6 USG) of water per flush.
- The Sanibest is simplicity itself to install; there are just four connections.
- The macerating pump is connected to the spigot of a horizontal outlet toilet.
- The toilet tank is connected to water supply.
- The macerating pump is connected to small diameter discharge pipe work.
- The macerating pump is connected to electrical supply.
- The Sanibest macerating system is comprised of a pressure chamber, which starts and stops the unit, and the motor, which drives the stainless steel macerator blades and pump.
- To learn more about the macerating process please refer to What is a macerator? in the Specification Tab. A normal operating cycle for Sanibest takes about 10-20 seconds depending upon the discharge pipe run configuration; power consumption is therefore minimal.
- The Sanibest is designed to provide vertical pumping up to 18 feet as well as a horizontal discharge, therefore a simple ball non-return valve is incorporated. This allows you to install a complete bathroom where previously this would have been impossible or where considerable capital equipment and structural work would have been necessary.
| |
Sanibest - Two Piece Round Bowl Toilet with Sanibest Grinder Pump - White
| Dimensions |
Motor |
Electrical supply |
Discharge |
Gravity Fall on Horizontal installations |
| 12in (H) x 21in (W) x 8in (D) |
Induction Motor (no carbon brushes or gears), tested over 50,000 cycles. 3600 rpm |
110-115V; 60Hz; 15 AMP; usage 9.0 AMP. Connect to Ground Fault Circuit Interrupter. |
Horizontally to 150 ft (50m) Pumps vertically to 18 ft (6m) |
1/4in per ft |
| Discharge Pipe Diameter |
Construction Materials |
Normal Running Time |
Water per Flush |
Discharge rate |
| 3/4in; 21mm |
Polypropylene, C.R.P., stainless steel, Neoprene Max. temp. 104°F; 40°C |
10-20 seconds subject to installation pipe run |
1.6 US gal; 6 liters |
Volume 10.88 gal/m; 40 l/m |
What is a Macerator? |
 |
To "macerate" is to soften, to break in pieces. Our Saniflo macerating systems use a rotating cutting blade to liquefy human waste and toilet paper. When mixed with flushing water the waste is pumped into a sanitary sewer as a fine slurry. |
| Installing a bathroom where you want is often difficult and sometimes even impossible. The main drainpipe is either too far away, or the new bathroom or sink will be lower than the drainpipe, making conventional installation unworkable. So what you need is the Saniflo up flush toilet and macerating pump that requires minimal construction work. |
 |
| Saniflo’s macerator units solve these problems, because they can grind and pump waste over a distance of 150 feet and up to a height of 18 feet. These systems automatically activate when required to reduce effluent to a slurry and pump it away to the soil stack, septic tank or sewer through small diameter discharge pipes. And here is how it works. |
 |
| 1. The toilet is flushed and the effluent is discharged by gravity through the rear spigot and into the macerator device. The effluent rises to a preset level, a micro-switch in the pressure chamber of the macerating device is activated. |
 |
|
| 2. Simple flapper style check valves on each of the side inlets close momentarily, while the blades inside rotate at 3,600 revolutions per minute and reduce any solids within the effluent into liquid, in about 3 or 4 seconds. |
 |
|
| 3. All waste is pumped into a sanitary gravity drain (a soil stack or a septic tank) through a standard pipe just ¾" or 1" in diameter. Once the liquid effluent is completely pumped out of the macerator, the micro-switch deactivates. |
 |
|
| 4. A non-return valve in the macerating unit prevents back-flow of the reduced effluent into the unit. The toilet refills with water. The macerator is now empty (apart from the water seal) and the system is ready for use again. |
 |
|
| NOTE: Toilet flush is given priority if another appliance is simultaneously discharged until the effluent from the toilet is sufficiently reduced, so that pressure switch is deactivated. \ | |
Sanibest - Two Piece Round Bowl Toilet with Sanibest Grinder Pump - White
|
|
|
icon.